- Open Access
Use of back-scatter electron signals to visualise cell/nanowires interactions in vitro and in vivo; frustrated phagocytosis of long fibres in macrophages and compartmentalisation in mesothelial cells in vivo
Particle and Fibre Toxicology volume 9, Article number: 34 (2012)
Frustrated phagocytosis has been stated as an important factor in the initiation of an inflammatory response after fibre exposure. The length of fibrous structures has been linked to the potential of fibres to induce adverse health effects for at least 40 years. However, we only recently reported for the first time the threshold length for fibre-induced inflammation in the pleural space and we implicated frustrated phagocytosis in the pro-inflammatory effects of long fibres. This study extends the examination of the threshold value for frustrated phagocytosis using well-defined length classes of silver nanowires (AgNW) ranging from 3–28 μm and describes in detail the morphology of frustrated phagocytosis using a novel technique and also describes compartmentalisation of fibres in the pleural space.
A novel technique, backscatter scanning electron microscopy (BSE) was used to study frustrated phagocytosis since it provides high-contrast detection of nanowires, allowing clear discrimination between the nanofibres and other cellular features. A human monocyte-derived macrophage cell line THP-1 was used to investigate cell-nanowire interaction in vitro and the parietal pleura, the site of fibre retention after inhalation exposure was chosen to visualise the cell- fibre interaction in vivo after direct pleural installation of AgNWs.
The length cut-off value for frustrated phagocytosis differs in vitro and in vivo. While in vitro frustrated phagocytosis could be observed with fibres ≥14 μm, in vivo studies showed incomplete uptake at a fibre length of ≥10 μm. Recently we showed that inflammation in the pleural space after intrapleural injection of the same nanofibre panel occurs at a length of ≥5 μm. This onset of inflammation does not correlate with the onset of frustrated phagocytosis as shown in this study, leading to the conclusion that intermediate length fibres fully enclosed within macrophages as well as frustrated phagocytosis are associated with a pro-inflammatory state in the pleural space. We further showed that fibres compartmentalise in the mesothelial cells at the parietal pleura as well as in inflammatory cells in the pleural space.
BSE is a useful way to clearly distinguish between fibres that are, or are not, membrane-bounded. Using this method we were able to show differences in the threshold length at which frustrated phagocytosis occurred between in vitro and in vivo models. Visualising nanowires in the pleura demonstrated at least 2 compartments – in leukocyte aggregations and in the mesothelium - which may have consequences for long term pathology in the pleural space including mesothelioma.
The toxicology of fibres is a sub-specialty of particle toxicology developed in response to the asbestos experience  but whose tenets have been used to quantify the hazards from vitreous fibres  organic fibres such as p-aramid  and most recently nanofibres [4, 5]. Current understanding of the fibre hazard is based on the ‘fibre pathogenicity paradigm’ which has predictive power and is the most robust structure/ toxicity relationship in particle toxicology. The paradigm identifies thinness, length and biopersistence as the 3 features that determine the pathogenic potential of any fibre sample . Thinness determines respirability, that is the likelihood that a fibre penetrates the respiratory tract beyond the ciliated airways  where most damage is likely to occur, whilst biopersistence determines whether the fibre will retain its structure integrity i.e. fibrous shape, during residence in the lung. If the fibre is composed of soluble components that are leached from the fibre under the conditions it encounters in vivo, then the fibre is likely to become weakened, break and become part of the short fibre pool. Short fibres are not pathogenic in the fibre sense, although they may have harmful effects as particles, whilst long fibres do cause fibre-type pathogenicity; this length-dependent pathogenicity has been demonstrated in numerous studies in vivo [6–8] and in vitro [9–11].
One major arbiter of length-dependent pathogenic effect is the alveolar macrophage and pleural macrophage whose normal function is to phagocytose fibres and clear them. Because of the unusual aerodynamics of fibres, extremely long fibres penetrate and deposit beyond the ciliated airways . Macrophages that attempt to phagocytose long fibres cannot enclose them leading to ‘frustrated phagocytosis’ as shown diagrammatically in Figure 1; in contrast short fibres are fully enclosed in the phagosomes (Figure 1).
We recently reported length-dependent effects of a range of fibres including asbestos , carbon nanotubes [12, 13], silver nanowires (AgNW)  and nickel nanowires (NiNW)  at the peritoneal and pleural mesothelial surfaces. All of these fibre types appear to comply with the fibre pathogenicity paradigm with length-dependent effects in the pleural space as a result of retention at stomata (3–10 μm in diameter) on the parietal pleura and frustrated phagocytosis. These data show persuasively that the length threshold for pleural retention of any fibres is 5 μm and that fibre shorter than this threshold are not retained and do not cause inflammation .
Whilst we evoked frustrated phagocytosis in the pro-inflammatory effects, we also noted that intermediate 5 μm length fibres, were fully enclosed by macrophages but were pro-inflammatory, as previously recorded . Due to restrictions on space we could not fully explore the morphological basis of this new effect and here we extend these findings to fully characterise fibre length effects particularly frustrated phagocytosis in vitro and in vivo. We utilised the technique of backscatter electron microscopy in particular to investigate this phenomenon. We also describe the retention of fibres in the parietal mesothelial layer, an anatomical region not hitherto identified a retention compartment for fibres.
Characteristic of the AgNW panel are summarised in Figure 2. The images illustrate the uniform distribution of the AgNWs with no aggregation being present. Complete characterisation of the AgNW panel was described previously by Schinwald et al. .
Membrane integrity and metabolic activity in the in vitro model
The in vitro experiments were based on a treatment dose which was non/low-toxicity to THP-1 cells in culture adjusted for each fibre length to produce approximately the same fibre number (Table 1). The 2 μg/cm2 dose based on AgNW14 was determined by measuring the membrane integrity via the release of lactate dehydrogenase (LDH) into the supernatant and cell proliferation of the THP-1 cells after 24 hour treatment; however, AgNW28 caused a significant decrease in membrane integrity and loss of proliferation and metabolic activity (Figure 3A,B).
Bright field microscopy of THP-1 cells after 4 hour exposure in vitro
THP-1 cells were exposed to the panel of AgNWs for 4 hours and bright field images were taken using a 60× magnification. THP-1 cells completely phagocytose AgNW3 (Figure 4A) and AgNW5 (Figure 4B). The fibres were fully taken up as indicated by the yellow circle. AgNW10 were mostly phagocytosed with only a small percentage of fibre-ends protruding out of the cells as indicated by the red arrow (Figure 4C). Frustrated phagocytosis was observed after treatment with AgNW14 and AgNW28. In Figure 5d the black arrow indicates a fibre shared by two cells and another fibre only partly enclosed by the cell (red arrow Figure 4D and E).
Characterisation of Cell/Nanowire interaction in vitro using BSE
Backscatter electron microscopy (BSE) enabled us to visualise the interaction of THP-1 macrophage cells with AgNW. We mainly focused on the uptake/phagocytosis of the five different size categories of AgNW to identify the cut-off value, at which frustrated phagocytosis occurs in vitro. Figure 5A-E show differentiated THP-1 macrophages after 4 hour treatment with AgNW3 (A), AgNW5 (B), AgNW10 (C), AgNW14 (D) and AgNW28 (E). In Figure 5A one external AgNW3 can be seen (white arrow) and a few AgNW3 can be seen just underneath the surface of a macrophage as indicated by the black arrow (Figure 5A insert). After treatment with AgNW5, nanowires were fully taken up by macrophages as indicated by the white arrow (Figure 5B insert). A small proportion of cells showing incomplete uptake of AgNW10 fibres could be observed as indicated by the white arrow (Figure 5C) however most of the fibres were membrane bound (black/white arrow) and therefore phagocytosed by the cells. Obvious frustrated phagocytosis could be observed from a nanowire length of 14 μm (Figure 5D) and 28 μm (Figure 5E). A much greater amount of AgNW was observed protruding through cells or shared between adjacent cells indicating frustrated phagocytosis (white arrow). The number of unphagocytosed fibres per cell was quantified and significantly increased with AgNW14 (p > 0.05) and AgNW28 (p > 0.001).
Uptake of AgNWs in pleural macrophages from pleural lavage
In Figure 6A a macrophage is shown from a pleural lavage after treatment with AgNW3. The macrophage could readily phagocytose a number of short (3 μm) AgNWs (Figure 6A). After treatment with AgNW5 (Figure 6B), again the nanowires were fully taken up by the pleural macrophages in the lavage fluid. However, AgNW10 (C), AgNW14 (D) and AgNW28 (E) could not be fully phagocytosed by the cells anymore, leading to frustrated phagocytosis. Enlargement of the pleural macrophages (Figure 6D) could be observed. Data from the same animals as described here were utilised in Schinwald et al.  where details of the inflammatory effects accompanying these cellular changes can be obtained.
Phagocytosis/frustrated phagocytosis in vivo on the parietal pleura surface 24 hour post exposure
Backscatter scanning electron microscopy examination was carried out on the macrophage accumulations on the parietal pleura samples from mice injected with AgNW3, AgNW5 and AgNW10 at 24 hour post intrapleural instillation in order to examine the development of interaction between the mesothelial cell layer/inflammatory cells on the surface. The dose of 5 μg per mouse used in this study lead to a significant increase in inflammation after treatment with AgNW5, AgNW10, AgNW14 and AgNW28 as previously reported . A dose response was performed by increasing the dose of AgNW3 up to 10 μg which resulted in no significant increase in inflammation. The dose of AgNW5 was decreased to 1 μg and 2.5 μg whereby 2.5 μg continuously showed significant inflammation . AgNW3 treatment was chosen to investigate if any short fibre were retained in the pleural space after intrapleural injection even though no inflammatory response was observed. AgNW5 and AgNW10 treatments were chosen since both treatments lead to a significant increase in pleural inflammation however differ in their interactions with pleural macrophages . No AgNW3 could be observed on the parietal pleura surface 24 hour post treatments confirming that short fibres are readily cleared from the pleural space. In contrast to AgNW3, both AgNW5 and AgNW10 lead to an aggregation of inflammatory cells on the surface of the parietal pleura with accumulation of nanowires within the lesion area (Figure 7A,C). Most AgNW5 were fully phagocytosed by pleural macrophages (Figure 7A, B and insert, stars). In comparison, AgNW10 showed a number of fibres only partly phagocytosed and therefore leading to frustrated phagocytosis (Figure 7C,D white arrow). Some AgNW5 and AgNW10 were not taken up by macrophages as indicated by the yellow arrows (Figure 7A,C). By looking at the surface with higher magnification unclosed membrane could be visualised in pleural macrophages phagocytosing AgNW10 (Figure 7D and insert, black arrows).
Phagocytosis/frustrated phagocytosis in vivo on the parietal pleura surface 1 week post exposure
BSEM of parietal pleura after 1 week treatment with AgNW5 are shown in Figure 8A,B,C and AgNW10 in Figure 8D,E,F. By 1 week, AgNW5 started to lose their integrity, presumably in the acidic conditions within a phagosome as seen in Figure 8A,B indicated by the black arrow. Non-dissolved fibres overlying the mesothelial cell layer appear intact in their morphology (Figure 8B, white arrow). Ghost-like structures of nanofibres which are covered by microvilli (Figure 8B,C star) could be seen. AgNW10 could be found either in accumulations of inflammatory cells which appeared denser and more granulomatous after 1 week (Figure 8D cross), or in the mesothelial cell layer (Figure 8D triangle). AgNW10 also started to lose integrity inside the phagocytic compartments of pleural macrophages (Figure 8E cross). Figure 8F shows AgNW10 partly membrane bound on the mesothelial cell layer. Data from the same animals as described here were utilised in Schinwald et al. .
Compartmentalisation of nanowires into mesothelial cells
So far, we hypothesised that after a prolonged exposure to fibres in general up to 7 days, the instilled fibres in the pleural space would either be cleared from the pleural space and enter the lymphatic drainage system or be accumulated in a granulomatous lesion on the parietal pleura at stomata . By using backscatter imaging, for the first time it was possible to visualise nanowires in the mesothelial cell layer of the parietal pleura. Both treatments, AgNW5 and AgNW10 (but not AgNW3 which were not observed as they had been cleared) showed nanofibres either on the surface of the mesothelial cells (black arrow Figure 9B) or taken up by these cells (white arrow Figure 9A,B). This is especially surprising for AgNW5, since pleural macrophages are able to phagocytose these fibres completely as shown in Figure 7B. By comparing the structure/shape of the nanowires associated with the mesothelial layer (Figure 9) and within macrophages (Figure 8B,E), it can quite clearly be seen that the nanowires are still intact after 1 week in the mesothelial layer whereas within the phago-lysosome of a macrophage the fibres start to degrade and lose integrity. These images show evidence that not all fibres longer than 5 μm are internalised by macrophages during the early inflammatory reaction, and that some are compartmentalised into the mesothelial layer which could lead to direct effects on the mesothelial cells and pleural diseases in a later stage if they are biopersistent.
The capacity of alveolar macrophages for phagocytosis and clearance of particles and fibres from the lung is of major relevance in pulmonary defence and development of lung and pleural diseases. In this study we addressed the length cut-off value at which frustrated phagocytosis occurs in vitro and in vivo. We recently defined the threshold length for inflammogenicity in the pleural space for a range of fibres including those used here . However in that paper we were unable, due to restrictions on space, to fully explore the role of frustrated phagocytosis nor fully describe the disposition of fibres in the pleural space. In the present paper we were able to quantitatively compare phagocytosis/ frustrated phagocytosis of 5 different lengths of silver nanofibres ranging from 3–28 μm where inflammogenicity was determined in a previous study . Thus far, the polydispersity of fibre length in samples including naturally occurring fibres and synthetic vitreous fibres prohibited the accurate investigation of the toxicity of various fibre lengths. The tight length classes of nanofibres used in this study, produced using nanotechnological methods, allowed us to perform a quantitative and qualitative comparison of the role of fibre length and frustrated phagocytosis in vitro and in vivo.
The use of a novel technique, backscatter electron microscopy allowed us to distinguish between membrane bound fibres and unphagocytosed fibres and to visualise the interaction of inflammatory cells with different length of nanofibres on the parietal pleura, the site of fibre retention in vivo.
The need for macrophages to internalise and therefore clear fibres from the lung and the pleural space has long been accepted  but the cut-off length below which complete internalisation of particles/fibres occurs is unknown. An extensive study has investigated the phagocytic capacity of murine bone marrow-derived macrophages to engulf various sizes of latex beads in a range of 13 μm to >30 μm in diameter . By measuring the bead diameter they calculated a phagocytosis capacity of 19.8 μm, which is 1.44 times the actual diameter of the cell. In regard to the phagocytosis of fibres by macrophages, Ye et al. investigated the role of glass fibre length in TNF-α production and NF-κB activation in a mouse macrophage cell line and correlated and increase in both cytokine level and transcription factor to incomplete phagocytosis of long fibres (17 μm) whereas short fibres (7 μm) were fully phagocytosed and therefore had less expression of the measured endpoints . These data correlate with our identified threshold length for frustrated phagocytosis in vitro, which is ≥ 14 μm.
An in vivo study performed by Oberdorster et al. assessed the clearance of small (~3 μm in diameter) and large (~10 μm in diameter) polystyrene microspheres in rat and identified minimal clearance of larger spheres after a 200 days post position period . This was considered to be due to impaired clearance of particles when the macrophage particle load is 60% of its normal volume.
Frustrated phagocytosis has been implicated to play a major role in the development of an inflammatory milieu after exposure to fibres in vitro [19, 20]. We recently demonstrated that frustrated phagocytosis is a major factor in the genesis of inflammation in the pleural space after deposition of long fibres whereby macrophages undergoing frustrated phagocytosis of the long fibres release factors that promote a potent pro-inflammatory cytokine response from adjacent mesothelial cells . In addition we have demonstrated that 5 μm is the threshold for pro-inflammatory effects of fibre in the pleural space for a wide range of fibers . However, so far frustrated phagocytosis has not been fully visualised in vivo in the pleura and the fibre length threshold for frustrated phagocytosis in vivo is unknown. Here we showed that the length cut off value at which long fibres can be fully phagocytosed by macrophages differs in vitro and in vivo. Whereas in vitro fibres of 10 μm could be completely phagocytosed, in vivo inflammatory cells on the parietal pleura showed incomplete uptake and frustrated phagocytosis of 10 μm fibres. There are a number of potential explanations for this anomalous difference between in vivo and in vitro length-dependent effect. The in vivo model is a pleural granuloma in mice and this is very different from the in vitro situation. Firstly the cells used in vitro are human cells, secondly they are a cell line and thirdly they are not in the granulomatous milieu but are spread out singly on plastic, submerged in medium with 10% serum, a very abnormal environment. We conclude that investigations on frustrated phagocytosis and its relation to the pathological effects of fibres need to be carried out in vivo although future work could be focussed on trying different cell lines and culture conditions with the aim of finding a better in vitro model that mimics the in vivo findings.
Interestingly, pleural injection of AgNW5 lead to significant inflammation in the pleural space  but was not associated with frustrated phagocytosis in vivo. These results show that frustrated phagocytosis is not solely responsible for the onset of an inflammatory reaction in the pleural space after exposure to fibrous particles and that fibres around 5 μm can be fully phagocytosed but nonetheless cause sufficient cellular stress to induce pro-inflammatory effects (Figure 10).
In this study we focused on the interaction of macrophages with nanofibres, however, our investigations of the parietal pleura revealed that intact nanofibres can also be found on the normal mesothelial cell layer after 1 week exposure. So far, we hypothesised that fibres, which are retained in the pleural space would be accumulated in lesions on the parietal pleura. In our study the mesothelial cells do not seem to be pro-inflammatory in this position as they have not attracted leukocytes to their vicinity and so their main effect may be by direct genotoxic or cytotoxic effects on the mesothelial cells. A lack of direct pro-inflammatory effect of the nanowires on the mesothelial cells would be consistent with our recent study on the interactions between long carbon nanotubes, macrophages and mesothelial cells in the genesis of inflammation. Work with long carbon nanotubes show that fibres interacting with macrophages cause the macrophages to release factors that evoke large scale production of inflammatory mediators by adjacent mesothelial cells . Activated mesothelial cells produce a number of pro-inflammatory mediators including prostaglandins, nitric oxide, reactive oxygen species, cytokines and growth factors. Prolonged release of these pro-inflammatory mediators due to retention of fibres on the mesothelial surface may play a role in stimulation of tumour growth . In contrast direct interaction between carbon nanotubes and mesothelial cells in vitro produced very little pro-inflammatory cytokine release by the mesothelial cells but did lead to significant membrane damage at higher carbon nanotube concentrations at a similar extent to that seen in macrophages . A study by Adamson reported that exposure to long (≤20 μm) crocidolite asbestos fibres lead to increased pleural mesothelial cell proliferation in mice but no uptake of fibres in mesothelial cells was observed and again an indirect effect of mitogens released by cells in the sub-pleural lung tissues was implicated .
Therefore nanofibres that escape macrophage phagocytosis and take up residence in the mesothelium may be relatively non-inflammatory but represent a direct genotoxic threat. The interaction of AgNW with mesothelial cells changed their biopersistent characteristics, since AgNW appeared intact in their shape compared to compartmentalisation in macrophages where dissolution is observed. Silver ion measurements may not be helpful in clarifying AgNW persistence either in vivo or in vitro to the complexity of interpreting the data due to silver chloride formation as discussed in Schinwald et al. .
Our findings suggest therefore the threshold length of 5 μm is a threshold for retention of fibres that has at least 2 sequels:- 1) inflammation in the pleural space ; 2) compartmentalisation and localisation of such fibres to the mesothelial layer.
The use of backscatter scanning electron microscopy enabled us to identifying frustrated phagocytosis in vitro and in vivo using metal-based nanofibre samples without the further need of nanofibre modification including radio labelling or fluorescence labelling to visualise their interaction with cells and tissue. The images and data provided in this study show a clear cut-off value for frustrated phagocytosis in vitro and in vivo (Figure 10). We could visualise the interaction of nanowires with pleural inflammatory cells in vivo and revealed that frustrated phagocytosis is not the only factor for the onset of pleural inflammation and 5 μm fibres can be fully enclosed but are still associated with inflammation as previously described . The contrast between the in vitro and in vivo finding for the length threshold for frustrated phagocytosis suggest that THP-1 macrophages do not provide a good model for the length dependent phagocytic events that occur in vivo in the murine pleural space. More research may provide a better in vitro model that mimics the in vivo effects. We also visualised the interaction of mesothelial cells with nanofibres and described a novel compartmentalisation of them in mesothelial cells which appeared to show different biopersistence characteristics compared to compartmentalisation in macrophages. However this needs to be confirmed by more quantitative studies rather than the merely descriptive data that are presented here.
Materials and methods
Backscatter electron signals by scanning electron microscopy
Elements with high atomic number (Z) such as silver reflect or back-scatter electrons more strongly than the lower Z light elements (predominantly H, C, N, O, P) of which cells are composed. Back-scattered electron imaging (BSE) is therefore a useful way to study frustrated phagocytosis since it provides high-contrast detection of nanowires, allowing clear discrimination between the nanofibres and other cellular features. Since the BSE signal from the fibres is attenuated by overlying cellular material, the method allows a clear distinction to be made between fibres that are, or are not, membrane-bounded, and can allow detection of fully phagocytosed fibres, which would not otherwise be detected in an SE image, provided they are at shallow depth within the cell.
Fibre panel and size distribution
The fibre panel consisted of five distinct length classes of silver nanowires, hereafter referred to as AgNW3, AgNW5, AgNW10, AgNW14 and AgNW28 whereby the subscript numbers indicate the average length of the nanowires. AgNW length diameter, contamination, soluble metal content, endotoxin level and dispertion was characterised as described previously by Schinwald et al.  (Figure 2). The samples were kindly provided by Seashell Technology, San Diego and synthesised using a polyol process as decribed in the US patent number 7,922,787 B2.
For light microscopy images 1 mg/ml of AgNWs were dispersed in 0.5% bovine serum albumin (BSA; Sigma-Aldrich, Poole, UK) and 10 μl of suspension was mixed in equal volume of glycerol (Sigma-Aldrich, Poole, UK) to reduce the flow of AgNW. The suspension was placed on a glass slide, covered with coverslip and images taken using QCapture Pro software (Media Cybernetics).
In vitro study
In vitro macrophages exposed to fibres of different lengths
The immortalised human monocytic cell line THP1 was used for in vitro studies. Cells were cultured in RPMI media supplemented with 10% heat inactivated FBS, 1% penicillin/streptomycin and 1% L-Glutamine (PAA, Austria). Prior to each treatment the cells were seeded in 24-well plates at a density of 0.5*106/ml in 500 μl medium containing 10% FBS and 10 ng/ml phorbol 12-myristate 13-acetate (PMA) (Sigma) for 2 days at 37°C in 5% CO2 atmosphere . Fibres were uniformly dispersed in cell culture medium (RPMI 1640) supplemented with 1% penicillin/streptomycin and 1% L-Glutamine (PAA, Austria) and 0.5% bovine serum albumin (BSA; Sigma-Aldrich, Poole, UK) and briefly vortexed. Cells were treated with AgNW equalised to fibre number since fibre exposure is regulated on the basis of the fibre number and so relative potency needs to be determined on a per-fibre basis. To equalise for fibre number a dose of 2 μg/cm2 for AgNW14 was chosen as the standard in vitro dose based on previous measurement of membrane integrity and proliferation. Based on 2 μg/cm2 for AgNW14, concentrations for the other length classes AgNW panel were calculated assuming that fibres thickness was constant in the different length classes (Table 1).
Measurement of membrane integrity and proliferation of THP-1
Cells were seeded at a concentration of 0.5*106 cells/ml and treated for 24 hours as described above. TritonX (Sigma) was used as a positive control for cell death and was added at a final concentration of 0.1% for 30 mins. After the treatment supernatant was centrifuged for 5 mins at 2000 rpm, transferred and centrifuged again for 5 mins at 13000 rpm. The conversion of lactate to pyruvate was detected using the Cytotoxicity Detection Lactate Dehydrogenase kit (Roche Diagnostics Ltd., Burgess Hill, UK) following the manufacturer’s instructions. A microplate reader (BioTek® SynergyHT) was used to measure the optical density at 490 nm. Results are given as the mean ± SEM of 5 independent experiments.
Cells in the culture dish were used to measure their proliferation and metabolic activity via a chemical reduction of AlamarBlue® (Invitrogen). 150 μl of PBS and 15 μl of AlamarBlue® was added to each well and incubated for 3 hours at 37°C in 5% CO2 atmosphere. Absorbance was monitored at 570 nm and 600 nm as a reference wavelength. Data are normalized to 600 nm value. Results are given as the mean ± SEM of 5 independent experiments.
Preparation for BSE
THP-1 cells were differentiated as described above and seeded into 24 well plates on Thermanox® Plastic Coverslips (NUNC™, Rochester, NY USA) at a density of 0.5*106/ml. The cells were treated for 4 hours using concentration as described above at 37°C in 5% CO2 atmosphere. After the treatment they were washed 5× with 0.1 M sodium cacodylate (pH 7.2) buffer. Overnight fixation was done in 3% glutaraldehyde/ 0.1 M sodium cacodylate (pH 7.2) buffer. After fixation the cells adherent to the coverslips were washed three times in sodium cacodylate buffer.
Bright field microscopy
THP-1 cells were differentiated as described above in a μ-dish (35 mm) (ibidi, Germany) and treated for 4 hours as described above. Brightfield microscope images were taken using Leica confocal laser scanning microscope SP5 at a 60× oil immersion objective lens.
In vivo study
Intra pleural injection of fibres
Fibres were uniformly dispersed in 0.5% bovine serum albumin (BSA; Sigma-Aldrich, Poole, UK)/saline at a concentration of 50 μg/ml which equates a dose of 5 μg per mouse and injected into the pleural cavity of female C57BI/6 mice (aged 8 weeks) at a volume of 100 μl per mouse as described previously by Schinwald et al. . We used a sleeve close to the tip of a 27 G needle to prevent it penetrating beyond the pleural space into the lung . Mice were euthanized after 24 hours (n = 4) and 7 days (n = 4) by asphyxiation in 100% CO2.
Lavage of pleural space
The pleural space was lavaged with three 1 ml washes of sterile saline and kept on ice. To separate the cellular fraction from the supernatant the lavage fluid was centrifuged for 5 minutes at 2000 rpm at 4°C in a Mistral 3000i centrifuge (Thermo Fisher Scientific, Inc., MA, USA). Cyto-centrifugation with following Diff-Quik staining using Diff-Quik stainset (Dade Behring Gmbh, Marburg, Germany) were prepared for visualising uptake of fibres in pleural macrophages.
Preparation parietal pleura for BSE
The lower right posterior portion of the chest wall, approximately an area of 1 cm × 0.5 cm along the spine was cut out from the mice after lavage, washed in ice-cold saline and fixed for 4 hours in 30% formalin. The tissue was excised from the surrounding tissue and fixed with 3% glutaraldehyde in 0.1 M Sodium Cacodylate buffer (pH 7.3) for 3 hours then washed in three 10 minute changes of 0.1 M Sodium Cacodylate buffer.
Cell and tissue preparation for BSE
Fixed samples were dehydrated in 50%, 70%, 90% and 100% normal grade acetones for 10 minutes each, then for a further two 10-minute changes in analar acetone. Dehydrated samples were critical point dried and mounted on SEM aliminium stubs and rotary-coated with about 8 nm of carbon in an Edwards 306A vacuum coating system (Edwards High Vacuum, Crawley, UK).
SEM of carbon-coated specimens was carried out using a Hitachi 4700 II field emission SEM (Hitachi High-Tech, Maidenhead, UK) at a beam accelerating voltage of 10 kV and a working distance of about 8 mm. Secondary electron (SE) and BSE images were taken simultaneously using an annular YAG crystal BSE detector and the upper SE detector to produce perfectly-synchronised image pairs. The two images were superimposed using Adobe Photoshop. The SE and BSE image were converted to grayscale, the BSE image was pasted into the SE image by using the layer function “lighten”. This newly merged image and the SE image were converted to RGB mode, and overlayed by pasting the red channel of the BSE image into the red channel of the greyscale SE image, thus colour coding in red the strong BSE signal from the nanowires, the SE image appearing in grey.
Methodology for quantifying unphagocytosed fibres
Image-Pro plus software (Media Cybernetics Inc., MD, USA) was used to measure the amount AgNW outside macrophages. The intensity of red pixels of the nanofibres differs if the fibre is taken up by a cell and therefore covered by a cell layer (lower intensity) or if the fibres is unphagocytosed (higher intensity). Using Image-Pro software, it was possible to specifically select the red pixel intensity of unphagocytosed cells which was expressed as object and area count. The number of objects (unphagocytosed fibres) was divided by the number of cells per image and expressed as unphagocytosed fibres per cell. Approximately 100 cells per image were counted (n = 3).
All data are shown as the mean ± s.e.m. and these were analysed using one-way analysis of variance (ANOVA). Multiple comparison were analysed using Tukey-HSD method and in all cases (GraphPad InStat Software Inc., CA, USA).
Backscatter scanning electron microscopy
Kamp DW: Asbestos-induced lung diseases: an update. Transl Res 2009, 153: 143–152. 10.1016/j.trsl.2009.01.004
Warheit DB, Driscoll KE, Oberdoerster G, Walker C, Kuschner M, Hesterberg TW: Contemporary issues in fiber toxicology. Fundam Appl Toxicol 1995, 25: 171–183. 10.1006/faat.1995.1053
Donaldson K: The inhalation toxicology of p-aramid fibrils. Crit Rev Toxicol 2009, 39: 487–500. 10.1080/10408440902911861
Donaldson K, Murphy FA, Duffin R, Poland CA: Asbestos, carbon nanotubes and the pleural mesothelium: a review of the hypothesis regarding the role of long fibre retention in the parietal pleura, inflammation and mesothelioma. Particle and Fibre Toxicology 2010, 7: 5. 10.1186/1743-8977-7-5
Donaldson K, Murphy F, Schinwald A, Duffin R, Poland CA: Identifying the pulmonary hazard of high aspect ratio nanoparticles to enable their safety-by-design. Nanomedicine (Lond) 2011, 6: 143–156. 10.2217/nnm.10.139
Wright GW, Kuschner M: The influence of varying lengths of glass and asbestos fibres on tissue response in guinea pigs. Inhaled Part 1975,4(Pt 2):455–744. 455–474.
Davis JM, Addison J, Bolton RE, Donaldson K, Jones AD, Smith T: The pathogenicity of long versus short fibre samples of amosite asbestos administered to rats by inhalation and intraperitoneal injection. Br J Exp Pathol 1986, 67: 415–430.
Donaldson K, Brown GM, Brown DM, Bolton RE, Davis JM: Inflammation generating potential of long and short fibre amosite asbestos samples. Br J Ind Med 1989, 46: 271–276.
Ye J, Shi X, Jones W, Rojanasakul Y, Cheng N, Schwegler-Berry D, et al.: Critical role of glass fiber length in TNF-alpha production and transcription factor activation in macrophages. Am J Physiol 1999, 276: L426-L434.
Donaldson K, Li XY, Dogra S, Miller BG, Brown GM: Asbestos-stimulated tumour necrosis factor release from alveolar macrophages depends on fibre length and opsonization. J Pathol 1992, 168: 243–248. 10.1002/path.1711680214
Poland CA, Byrne F, Cho WS, Prina-Mello A, Murphy FA, Davies GL, et al.: Length-dependent pathogenic effects of nickel nanowires in the lungs and the peritoneal cavity. Nanotoxicology 2011. [Epub ahead of print].
Poland CA, Duffin R, Kinloch I, Maynard A, Wallace WA, Seaton A, et al.: Carbon nanotubes introduced into the abdominal cavity of mice show asbestos-like pathogenicity in a pilot study. Nat Nanotechnol 2008, 3: 423–428. 10.1038/nnano.2008.111
Murphy FA, Poland CA, Rodger D, Al-Jamal KT, Hanene A-B, Antonio N, et al.: Length-dependent retention of carbon nanotubes in the pleural space of mice initiates sustained inflammation and progressive fibrosis on the parietal pleura. Am J Pathol 2011, 178: 2587–2600. 10.1016/j.ajpath.2011.02.040
Schinwald A, Murphy F, Prina-Mello A, Poland CA, Byrne F, Glass JR, et al.: The threshold length for fibre-induced acute pleural inflammation: shedding light on the early events in asbestos-induced mesothelioma. Toxicol Sci 2012. Ref Type: In Press.
Boutin C, Dumortier P, Rey F, Viallat JR, De Vuyst P: Black spots concentrate oncogenic asbestos fibers in the parietal pleura. Thoracoscopic and mineralogic study. Am J Respir Crit Care Med 1996, 153: 444–449.
Lehnert BE: Pulmonary and thoracic macrophage subpopulations and clearance of particles from the lung. Environ Health Perspect 1992, 97: 17–46.
Cannon GJ, Swanson JA: The macrophage capacity for phagocytosis. J Cell Sci 1992, 101: 907–913.
Oberdorster G, Ferin J, Morse P, Corson NM, Morrow PE: Volumetric alveolar macrophage (AM) burden as a mechanism of impaired AM mediated particle clearance during chronic dust overloading of the lung. J Aerosol Med 1988, 1: A207.
Brown DM, Kinloch IA, Bangert U, Windle AH, Walter DM, Walker GS, et al.: An in vitro study of the potential of carbon nanotubes and nanofibres to induce inflammatory mediators and frustrated phagocytosis. Carbon 2007, 45: 1743–1756. 10.1016/j.carbon.2007.05.011
Murphy FA, Schinwald A, Poland CA, Donaldson K: The mechanism of pleural inflammation by long carbon nanotubes: interaction of long fibres with macrophages stimulates them to amplify pro-inflammatory responses in mesothelial cells. Part Fibre Toxicol 2012, 9: 8. 10.1186/1743-8977-9-8
Mutsaers SE: Mesothelial cells: their structure, function and role in serosal repair. Respirology 2002, 7: 171–191. 10.1046/j.1440-1843.2002.00404.x
Adamson IR: Early mesothelial cell proliferation after asbestos exposure: In vivo and in vitro studies. Environ Health Perspect 1997, 105: 1205–1208.
Soligo D, de Harven E, Nava MT, Lambertenghi-Deliliers G, Müeller M, Becker RP, Boyde A, Wolosewick JJ: Immunocytochemistry with back-scattered electron. In The science of Biological specimen preparation for microscopy and microanalysis. Scanning Microscopy 1985, 289–297.
Jeffree CE, Rixon HW, Brown G, Aitken J, Sugrue RJ: Distribution of the attachment (G) glycoprotein and GM1 within the envelope of mature respiratory syncytial virus filaments revealed using field emission scanning electron microscopy. Virology 2003, 306: 254–267. 10.1016/S0042-6822(02)00016-8
Park EK, Jung HS, Yang HI, Yoo MC, Kim C, Kim KS: Optimized THP-1 differentiation is required for the detection of responses to weak stimuli. Inflamm Res 2007, 56: 45–50. 10.1007/s00011-007-6115-5
We thank Chris Jeffree for specialist input in BSM and S. Mitchell (University of Edinburgh) for sample preparation for SEM and technical assistance and the Colt Foundation (A.S., K.D) for financial support. We also thank James R. Glass, Janet C. Dickerson and David A. Schultz from Seashell Technology for providing the AgNW samples.
The authors declare that they have no competing interests.
A.S. conceived and designed the experiments, analysed the data and wrote the manuscript. K.D. initiated the study, oversaw all experimental work and contributed to manuscript preparation. All authors read and approved the final manuscript.
Authors’ original submitted files for images
Below are the links to the authors’ original submitted files for images.
About this article
Cite this article
Schinwald, A., Donaldson, K. Use of back-scatter electron signals to visualise cell/nanowires interactions in vitro and in vivo; frustrated phagocytosis of long fibres in macrophages and compartmentalisation in mesothelial cells in vivo. Part Fibre Toxicol 9, 34 (2012) doi:10.1186/1743-8977-9-34
- Backscatter scanning electron microscopy (BSE)
- Frustrated phagocytosis
- THP-1 macrophages
- Pleural macrophages
- Parietal pleura mesothelium